Diamond Aerosol Spray
Refer to the original PDF for tables, figures and page layout.
Page 1\n \nPage 1/10\nSafety Data Sheet\nacc. to OSHA HCS\nPrinting date 07/02/2024\nLast revision 06/01/2024\nVersion 6.0\n59.1.0\n* 1 Identification\n· Product name: Diamond Aerosol Spray\n· Part number: 90-173000 - 90-173025\n· Application of the substance / the mixture Polishing solution\n· Details of the supplier of the safety data sheet\n· Manufacturer/Supplier:\nAllied High Tech Products Inc.\n16207 Carmenita Road\nUSA-Cerritos, CA, 90703\nUSA\ninfo@alliedhightech.com\n· Information department: Product safety department\n· Emergency telephone number:\nDuring normal opening times: +1 (310) 635-2466\nChemtrec: +1 (202) 483-7616\n2 Hazard(s) identification\n· Classification of the substance or mixture\nGHS02 Flame\nFlammable Aerosols 1\nH222 Extremely flammable aerosol.\nGHS04 Gas cylinder\nGases under Pressure - Compressed gas\nH280 Contains gas under pressure; may explode if heated.\nGHS08 Health hazard\nCarcinogenicity 2\nH351 Suspected of causing cancer.\nSpecific Target Organ Toxicity - Single Exposure 1 H370 Causes damage to the central nervous system and the cardiovascular system.\nGHS07\nEye Irritation 2A\nH319 Causes serious eye irritation.\nSimple Asphyxiant\n \nMay displace oxygen and cause rapid suffocation.\n· Label elements\n· GHS label elements The product is classified and labeled according to the Globally Harmonized System (GHS).\n(Contd. on page 2)\n\n\nPage 2\nPage 2/10\nSafety Data Sheet\nacc. to OSHA HCS\nPrinting date 07/02/2024\nLast revision 06/01/2024\nVersion 6.0\nProduct name: Diamond Aerosol Spray\n(Contd. of page 1)\n59.1.0\n· Hazard pictograms\nGHS02\nGHS04\nGHS07\nGHS08\n· Signal word Danger\n· Hazard-determining components of labeling:\nmethyl isobutyl ketone\nmethyl alcohol\n· Hazard statements\nExtremely flammable aerosol.\nContains gas under pressure; may explode if heated.\nCauses serious eye irritation.\nSuspected of causing cancer.\nCauses damage to the central nervous system and the cardiovascular system.\nMay displace oxygen and cause rapid suffocation.\n· Precautionary statements\nObtain special instructions before use.\nDo not handle until all safety precautions have been read and understood.\nKeep away from heat/sparks/open flames/hot surfaces. - No smoking.\nDo not spray on an open flame or other ignition source.\nPressurized container: Do not pierce or burn, even after use.\nDo not breathe dust/fume/gas/mist/vapors/spray.\nWash thoroughly after handling.\nDo not eat, drink or smoke when using this product.\nWear protective gloves/protective clothing/eye protection/face protection.\nIf in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing.\nIF exposed or concerned: Get medical advice/attention.\nSpecific treatment (see on this label).\nIf eye irritation persists: Get medical advice/attention.\nStore locked up.\nProtect from sunlight. Store in a well-ventilated place.\nProtect from sunlight. Do not expose to temperatures exceeding 50°C/122°F.\nDispose of contents/container in accordance with local/regional/national/international regulations.\n3 Composition/information on ingredients\n· Chemical characterization: Mixtures\n· Description: Mixture of the substances listed below with nonhazardous additions.\n· Hazardous components and components with occupational exposure limits:\n68476-86-8 Petroleum gases, liquefied, sweetened\n Flammable Gases 1, H220;\n Gases under Pressure - Compressed gas, H280\n40-50%\n64-17-5 ethyl alcohol\n Flammable Liquids 2, H225\n30-40%\n67-63-0 isopropyl alcohol\n Flammable Liquids 2, H225;\n Eye Irritation 2A, H319; Specific Target Organ Toxicity - Single Exposure 3,\nH336\n10%\n67-56-1 methyl alcohol\n Flammable Liquids 2, H225;\n Acute Toxicity - Oral 3, H301; Acute Toxicity - Dermal 3, H311; Acute\nToxicity - Inhalation 3, H331;\n Specific Target Organ Toxicity - Single Exposure 1, H370\n3-<5%\n108-10-1 methyl isobutyl ketone\n Flammable Liquids 2, H225;\n Carcinogenicity 2, H351;\n Acute Toxicity - Inhalation 4, H332; Eye Irritation\n2A, H319; Specific Target Organ Toxicity - Single Exposure 3, H336\n1-5%\n(Contd. on page 3)\n\n\nPage 3\nPage 3/10\nSafety Data Sheet\nacc. to OSHA HCS\nPrinting date 07/02/2024\nLast revision 06/01/2024\nVersion 6.0\nProduct name: Diamond Aerosol Spray\n(Contd. of page 2)\n59.1.0\n· Non-hazardous components:\n7732-18-5 water, distilled, conductivity or of similar purity\n1-5%\n7782-40-3 Diamond\n≤1%\n· Additional information:\nWater is a byproduct of ethyl alcohol.\nThe specific chemical identity and/or exact percentage of the composition has been withheld as a trade secret.\n4 First-aid measures\n· Description of first aid measures\n· After inhalation: Supply fresh air; consult doctor in case of complaints.\n· After skin contact: Generally the product does not irritate the skin.\n· After eye contact: Rinse opened eye for several minutes under running water. If symptoms persist, consult a doctor.\n· After swallowing: If symptoms persist consult doctor.\n· Information for doctor:\n· Most important symptoms and effects, both acute and delayed\nDisorientation\nUnconsciousness\nBreathing difficulty\nCoughing\nEye irritation\n· Indication of any immediate medical attention and special treatment needed No further relevant information available.\n5 Fire-fighting measures\n· Extinguishing media\n· Suitable extinguishing agents: CO2, extinguishing powder or water spray. Fight larger fires with water spray or alcohol resistant foam.\n· Special hazards arising from the substance or mixture During heating or in case of fire poisonous gases are produced.\n· Advice for firefighters\n· Protective equipment: Wear fully protective suit.\n6 Accidental release measures\n· Personal precautions, protective equipment and emergency procedures\nWear protective equipment. Keep unprotected persons away.\nEnsure adequate ventilation\nKeep away from ignition sources\n· Environmental precautions:\nDo not allow product to reach sewage system or any water course.\nDo not allow to enter sewers/ surface or ground water.\n· Methods and material for containment and cleaning up:\nDispose contaminated material as waste according to section 13.\nEnsure adequate ventilation.\n· Reference to other sections\nSee Section 7 for information on safe handling.\nSee Section 8 for information on personal protection equipment.\nSee Section 13 for disposal information.\n7 Handling and storage\n· Handling:\n· Precautions for safe handling\nProtect from heat and direct sunlight.\nEnsure proper ventilation/exhaustion at workplaces.\nOpen and handle receptacle with care.\n· Information about protection against explosions and fires:\nDo not spray on a naked flame or any incandescent material.\nKeep ignition sources away - Do not smoke.\n(Contd. on page 4)\n\n\nPage 4\nPage 4/10\nSafety Data Sheet\nacc. to OSHA HCS\nPrinting date 07/02/2024\nLast revision 06/01/2024\nVersion 6.0\nProduct name: Diamond Aerosol Spray\n(Contd. of page 3)\n59.1.0\nPressurized container: protect from sunlight and do not expose to temperatures exceeding 50°C, i.e. electric lights. Do not pierce or burn,\neven after use.\n· Conditions for safe storage, including any incompatibilities\n· Storage:\n· Requirements to be met by storerooms and receptacles: Observe official regulations on storing packagings with pressurized containers.\n· Information about storage in one common storage facility: Not required.\n· Further information about storage conditions:\nKeep receptacle tightly sealed.\nStore receptacle in a well ventilated area.\n· Specific end use(s) No further relevant information available.\n8 Exposure controls/personal protection\n· Additional information about design of technical systems: No additional data. See 7.\n· Control parameters\n· Components with limit values that require monitoring at the workplace:\nThe following constituents are the only constituents of the product which have a PEL, TLV or other recommended exposure limit.\nAt this time, the remaining constituent has no known exposure limits.\n64-17-5 ethyl alcohol\nPEL Long-term value: 1900 mg/m³, 1000 ppm\nREL Long-term value: 1900 mg/m³, 1000 ppm\nTLV Short-term value: 1000 ppm\nA3\n67-63-0 isopropyl alcohol\nPEL Long-term value: 980 mg/m³, 400 ppm\nREL Short-term value: 1225 mg/m³, 500 ppm\nLong-term value: 980 mg/m³, 400 ppm\nTLV Short-term value: 400 ppm\nLong-term value: 200 ppm\nBEI, A4\n67-56-1 methyl alcohol\nPEL Long-term value: 260 mg/m³, 200 ppm\nREL Short-term value: 325 mg/m³, 250 ppm\nLong-term value: 260 mg/m³, 200 ppm\nSkin\nTLV Short-term value: 250 ppm\nLong-term value: 200 ppm\nSkin; BEIc\n108-10-1 methyl isobutyl ketone\nPEL Long-term value: 410 mg/m³, 100 ppm\nREL Short-term value: 300 mg/m³, 75 ppm\nLong-term value: 205 mg/m³, 50 ppm\nTLV Short-term value: 75 ppm\nLong-term value: 20 ppm\nBEI, A3\n· Ingredients with biological limit values:\n67-63-0 isopropyl alcohol\nBEI 40 mg/L\nMedium: urine\nTime: end of shift at end of workweek\nParameter: Acetone (background, nonspecific)\n(Contd. on page 5)\n\n\nPage 5\nPage 5/10\nSafety Data Sheet\nacc. to OSHA HCS\nPrinting date 07/02/2024\nLast revision 06/01/2024\nVersion 6.0\nProduct name: Diamond Aerosol Spray\n(Contd. of page 4)\n59.1.0\n67-56-1 methyl alcohol\nBEI 15 mg/L\nMedium: urine\nTime: end of shift\nParameter: Methanol (background, nonspecific)\n108-10-1 methyl isobutyl ketone\nBEI 1 mg/L\nMedium: urine\nTime: end of shift\nParameter: MIBK\n· Exposure controls\n· Personal protective equipment:\n· General protective and hygienic measures:\nKeep away from foodstuffs, beverages and feed.\nImmediately remove all soiled and contaminated clothing.\nWash hands before breaks and at the end of work.\nStore protective clothing separately.\nAvoid contact with the eyes.\nAvoid contact with the eyes and skin.\n· Breathing equipment: Use suitable respiratory protective device when high concentrations are present.\n· Protection of hands:\nDue to missing tests no recommendation to the glove material can be given for the product/ the preparation/ the chemical mixture.\nProtective gloves\nThe glove material has to be impermeable and resistant to the product/ the substance/ the preparation.\nSelection of the glove material on consideration of the penetration times, rates of diffusion and the degradation\n· Material of gloves\nThe selection of the suitable gloves does not only depend on the material, but also on further marks of quality and varies from manufacturer\nto manufacturer. As the product is a preparation of several substances, the resistance of the glove material can not be calculated in advance\nand has therefore to be checked prior to the application.\n· Eye protection:\nTightly sealed goggles\n9 Physical and chemical properties\n· Information on basic physical and chemical properties\n· General Information\n· Appearance:\nForm:\nAerosol\nColor:\nAccording to product specification\n· Odor:\nAlcohol-like\n· Odor threshold:\nNot determined.\n· pH-value:\nNot determined.\n· Change in condition\nMelting point/Melting range:\nUndetermined.\nBoiling point/Boiling range:\n78 °C (172.4 °F)\n· Flash point:\n-88.3 °C (-126.9 °F)\n(Contd. on page 6)\n\n\nPage 6\nPage 6/10\nSafety Data Sheet\nacc. to OSHA HCS\nPrinting date 07/02/2024\nLast revision 06/01/2024\nVersion 6.0\nProduct name: Diamond Aerosol Spray\n(Contd. of page 5)\n59.1.0\n· Flammability (solid, gaseous):\nNot applicable.\n· Auto igniting:\n425 °C (797 °F)\n· Decomposition temperature:\nNot determined.\n· Ignition temperature:\nProduct is not selfigniting.\n· Danger of explosion:\nProduct is not explosive. However, formation of explosive air/vapor mixtures are possible.\n· Explosion limits:\nLower:\n1.8 Vol %\nUpper:\n9.5 Vol %\n· Vapor pressure at 20 °C (68 °F):\n64 hPa (48 mm Hg)\n· Density:\nNot determined.\n· Relative density\nNot determined.\n· Vapor density\n1.6-1.9 (Air = 1)\n· Specific gravity:\n0.8 (water = 1)\n· Evaporation rate\nNot applicable.\n· Solubility in / Miscibility with\nWater:\nFully miscible.\n· Partition coefficient (n-octanol/water): Not determined.\n· Viscosity:\nDynamic:\nNot determined.\nKinematic:\nNot determined.\n· Solvent content:\nOrganic solvents:\n52.3 %\nWater:\n3.5 %\nVOC content:\n52.25 %\n0.0 g/l / 0.00 lb/gal\nSolids content:\n1.0 %\n· Other information\nNo further relevant information available.\n10 Stability and reactivity\n· Reactivity No further relevant information available.\n· Chemical stability\n· Thermal decomposition / conditions to be avoided: No decomposition if used according to specifications.\n· Possibility of hazardous reactions No dangerous reactions known.\n· Conditions to avoid\nKeep away from heat.\nKeep away from open flames. - No smoking.\nKeep away from oxidising agents and acidic substances.\n· Incompatible materials: No further relevant information available.\n· Hazardous decomposition products:\nFormaldehyde\nCarbon monoxide and carbon dioxide\n· Additional information: Hazardous decomposition products may form during combustion.\n(Contd. on page 7)\n\n\nPage 7\nPage 7/10\nSafety Data Sheet\nacc. to OSHA HCS\nPrinting date 07/02/2024\nLast revision 06/01/2024\nVersion 6.0\nProduct name: Diamond Aerosol Spray\n(Contd. of page 6)\n59.1.0\n11 Toxicological information\n· Information on toxicological effects\n· Acute toxicity:\n· LD/LC50 values that are relevant for classification:\nATE (Acute Toxicity Estimate)\nOral\nLD50\n2,840 mg/kg\nDermal\nLD50\n8,520 mg/kg\nInhalative LC50/4 h 62.6-72.2 mg/l\n 64-17-5 ethyl alcohol\nOral\nLD50\n7,060 mg/kg (rat)\nDermal\nLD50\n15,800 mg/kg (rabbit)\nInhalative LC50/4 h 20,000 mg/l (rat)\n67-63-0 isopropyl alcohol\nOral\nLD50\n5,045 mg/kg (rat)\nDermal\nLD50\n12,800 mg/kg (rabbit)\nInhalative LC50/4 h 30 mg/l (rat)\n67-56-1 methyl alcohol\nOral\nLD50\n100 mg/kg (ATE)\nDermal\nLD50\n300 mg/kg (ATE)\nInhalative LC50/4 h 3 mg/l (ATE)\n108-10-1 methyl isobutyl ketone\nOral\nLD50\n2,080 mg/kg (rat)\nDermal\nLD50\n16,000 mg/kg (rab)\nInhalative LC50/4 h 11 mg/l (ATE)\n8.3-16.6 mg/l (rat)\n· Primary chemical irritant effect:\n· on the skin: No irritant effect.\n· on the eye: Irritating effect.\n· Sensitization: No sensitizing effects known.\n· Additional toxicological information:\n· Carcinogenic categories\n· IARC (International Agency for Research on Cancer)\n64-17-5 ethyl alcohol\n1 \n67-63-0 isopropyl alcohol\n3 \n108-10-1 methyl isobutyl ketone\n2B\n· NTP (National Toxicology Program)\nNone of the ingredients is listed.\n· OSHA-Ca (Occupational Safety & Health Administration)\nNone of the ingredients is listed.\n12 Ecological information\n· Toxicity\n· Aquatic toxicity: No further relevant information available.\n· Persistence and degradability No further relevant information available.\n· Behavior in environmental systems:\n· Bioaccumulative potential No further relevant information available.\n(Contd. on page 8)\n\n\nPage 8\nPage 8/10\nSafety Data Sheet\nacc. to OSHA HCS\nPrinting date 07/02/2024\nLast revision 06/01/2024\nVersion 6.0\nProduct name: Diamond Aerosol Spray\n(Contd. of page 7)\n59.1.0\n· Mobility in soil No further relevant information available.\n· Additional ecological information:\n· General notes:\nWater hazard class 1 (Self-assessment): slightly hazardous for water\nDo not allow undiluted product or large quantities of it to reach ground water, water course or sewage system.\n· Results of PBT and vPvB assessment\n· PBT: Not applicable.\n· vPvB: Not applicable.\n· Other adverse effects No further relevant information available.\n13 Disposal considerations\n· Waste treatment methods\n· Recommendation: Contact waste processors for recycling information.\n· Uncleaned packagings:\n· Recommendation: Disposal must be made according to official regulations.\n· Recommended cleansing agent: Water, if necessary with cleansing agents.\n14 Transport information\n· UN-Number\n· DOT, IMDG, IATA\nUN1950\n· UN proper shipping name\n· DOT\nAerosols, flammable\n· IMDG\nAEROSOLS\n· IATA\nAEROSOLS, flammable\n· Transport hazard class(es)\n· DOT\n· Class\n2.1 Gases\n· Label\n2.1\n· IMDG, IATA\n· Class\n2.1 Gases\n· Label\n2.1\n· Packing group\n· DOT, IMDG, IATA\nnot regulated\n· Environmental hazards:\n· Marine pollutant:\nNo\n· Special precautions for user\nWarning: Gases\n· Hazard identification number (Kemler code):\n- \n· EMS Number:\nF-D,S-U\n(Contd. on page 9)\n\n\nPage 9\nPage 9/10\nSafety Data Sheet\nacc. to OSHA HCS\nPrinting date 07/02/2024\nLast revision 06/01/2024\nVersion 6.0\nProduct name: Diamond Aerosol Spray\n(Contd. of page 8)\n59.1.0\n· Stowage Code\nSW1 Protected from sources of heat.\nSW22 For AEROSOLS with a maximum capacity of 1 litre: Category\nA. For AEROSOLS with a capacity above 1 litre: Category B. For\nWASTE AEROSOLS: Category C, Clear of living quarters.\n· Segregation Code\nSG69 For AEROSOLS with a maximum capacity of 1 litre:\nSegregation as for class 9. Stow "separated from" class 1 except for\ndivision 1.4.\nFor AEROSOLS with a capacity above 1 litre:\nSegregation as for the appropriate subdivision of class 2.\nFor WASTE AEROSOLS:\nSegregation as for the appropriate subdivision of class 2.\n· Transport in bulk according to Annex II of MARPOL73/78 and\nthe IBC Code\nNot applicable.\n· Transport/Additional information:\n· DOT\n· Quantity limitations\nOn passenger aircraft/rail: 75 kg\nOn cargo aircraft only: 150 kg\n· Limited quantities (LQ)\n1L\n· Transport category\n2 \n· Tunnel restriction code\nD \n· IMDG\n· Limited quantities (LQ)\n1L\n· Excepted quantities (EQ)\nCode: E0\nNot permitted as Excepted Quantity\n· UN "Model Regulation":\nUN 1950 AEROSOLS, 2.1\n15 Regulatory information\n· Safety, health and environmental regulations/legislation specific for the substance or mixture\nNo further relevant information available.\n· Sara\n· Section 355 (extremely hazardous substances):\nNone of the ingredients is listed.\n· Section 313 (Specific toxic chemical listings):\n67-63-0 isopropyl alcohol\n67-56-1 methyl alcohol\n108-10-1 methyl isobutyl ketone\n· TSCA (Toxic Substances Control Act):\nAll components have the value ACTIVE.\n· Hazardous Air Pollutants\n67-56-1 methyl alcohol\n108-10-1 methyl isobutyl ketone\n· Proposition 65\n· Chemicals known to cause cancer:\n108-10-1 methyl isobutyl ketone\n· Chemicals known to cause reproductive toxicity for females:\nNone of the ingredients is listed.\n· Chemicals known to cause reproductive toxicity for males:\nNone of the ingredients is listed.\n(Contd. on page 10)\n\n\nPage 10\nPage 10/10\nSafety Data Sheet\nacc. to OSHA HCS\nPrinting date 07/02/2024\nLast revision 06/01/2024\nVersion 6.0\nProduct name: Diamond Aerosol Spray\n(Contd. of page 9)\n59.1.0\n· Chemicals known to cause developmental toxicity:\n64-17-5 ethyl alcohol\n67-56-1 methyl alcohol\n108-10-1 methyl isobutyl ketone\n· Chemical safety assessment: A Chemical Safety Assessment has not been carried out.\n16 Other information\nTo the best of our knowledge, the information contained herein is accurate. However, it does not describe a guarantee of product properties\nand does not establish a contractual legal relationship.\n· Department issuing SDS: Technical Services\n· Contact: Pablo Mendoza\n· Last revision / supersedes version: 06/01/2024 / 5.0\n· Supersedes date: 06/01/2022\n· Abbreviations and acronyms:\nADR: Accord relatif au transport international des marchandises dangereuses par route (European Agreement Concerning the International Carriage of Dangerous Goods by\nRoad)\nIMDG: International Maritime Code for Dangerous Goods\nDOT: US Department of Transportation\nIATA: International Air Transport Association\nEINECS: European Inventory of Existing Commercial Chemical Substances\nELINCS: European List of Notified Chemical Substances\nCAS: Chemical Abstracts Service (division of the American Chemical Society)\nVOC: Volatile Organic Compounds (USA, EU)\nLC50: Lethal concentration, 50 percent\nLD50: Lethal dose, 50 percent\nPBT: Persistent, Bioaccumulative and Toxic\nvPvB: very Persistent and very Bioaccumulative\nOSHA: Occupational Safety & Health\nTLV: Threshold Limit Value\nPEL: Permissible Exposure Limit\nREL: Recommended Exposure Limit\nBEI: Biological Exposure Limit\nFlammable Gases 1: Flammable gases – Category 1\nFlammable Aerosols 1: Aerosols – Category 1\nGases under Pressure - Compressed gas: Gases under pressure – Compressed gas\nFlammable Liquids 2: Flammable liquids – Category 2\nAcute Toxicity - Oral 3: Acute toxicity – Category 3\nAcute Toxicity - Inhalation 4: Acute toxicity – Category 4\nEye Irritation 2A: Serious eye damage/eye irritation – Category 2A\nCarcinogenicity 2: Carcinogenicity – Category 2\nSpecific Target Organ Toxicity - Single Exposure 1: Specific target organ toxicity (single exposure) – Category 1\nSpecific Target Organ Toxicity - Single Exposure 3: Specific target organ toxicity (single exposure) – Category 3\n· * Data compared to the previous version altered. \n